1994 BMW 525i Touring
Fuel Economy Overview
The 1994 BMW 525i Touring achieves an EPA-estimated 19 MPG in combined city and highway driving, with 16 MPG in the city and 23 MPG on the highway. Powered by a 2.5L 6-cylinder engine paired with a automatic 4-spd, this small station wagons features Rear-Wheel Drive drive.
In terms of environmental impact, the 1994 525i Touring produces approximately 468 grams of CO2 per mile. This figure is measured under standardized EPA test conditions and represents tailpipe emissions only. For context, the average new vehicle sold in the United States produces approximately 400 grams of CO2 per mile, meaning this 525i Touring has higher-than-average emissions in this regard.
The estimated annual fuel cost for this vehicle is $3,650, based on 15,000 miles of driving per year and current national average fuel prices. Compared to the average new vehicle, you would save $7,500 over a 5-year period. This calculation accounts for differences in fuel consumption efficiency and provides a practical measure of long-term ownership costs attributable to fuel economy.
Energy DNA
Green Scorecard
Personalized Commute CalculatorEPA defaults to 55% City / 45% Hwy
Adjust the slider to match your daily driving habits. City driving involves stop-and-go traffic under 45mph, while highway driving represents sustained speeds over 55mph.
Aerodynamic Speed Penalty
EPA highway tests average roughly 48 mph. Driving at 75 mph increases aerodynamic drag exponentially. Expect your real-world highway fuel economy to drop by roughly 15-20% at interstate speeds.
5-Year Total Cost of Ownership
Recall Intelligence
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence & Remedy
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & Remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Consequence & Remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
THE DOUBLE-LOCK FEATURE CAN ENGAGE WITH OCCUPANTS AND THE DOOR/IGNITION KEY INSIDE THE VEHICLE.
Consequence & Remedy
Consequence: THE OCCUPANTS OF THE VEHICLE WOULD BE UNABLE TO EXIT EITHER FROM THE DOORS OR FROM THE WINDOWS OF THE VEHICLE. DRIVE-AWAY PROTECTION WOULD PREVENT THE ENGINE FROM STARTING.
Remedy: DEALERS WILL REPLACE THE GENERAL CONTROL MODULE WITH ONE CONTAINING THE REVISED SOFTWARE TO PERMIT WINDOW OPENING WITH THE DOUBLE-LOCK ENGAGED AND KEY IN THE IGNITION.
Loading live complaint data...
Looking for comprehensive historical data?
NHTSA FARS (Fatal Crash History) and broader generational safety trends are aggregated at the model level rather than by specific engine configurations. View the complete historical data profile for all BMW 525i Touring configurations.
Similar 1994 Small Station Wagons Alternatives
1994 Audi 100 Wagon
2.8L 6-cyl Front-Wheel Drive
1994 Audi 100 quattro Wagon
2.8L 6-cyl 4-Wheel or All-Wheel Drive
1994 BMW 530i Touring
3L 8-cyl Rear-Wheel Drive
1994 Chevrolet Cavalier Wagon
3.1L 6-cyl Front-Wheel Drive
1994 Subaru Legacy Wagon AWD Turbo
2.2L 4-cyl 4-Wheel or All-Wheel Drive
1994 BMW 530i Touring
3.1L 8-cyl Rear-Wheel Drive
Fuel Cost Analysis
Based on 15,000 miles/year and current fuel prices.
Efficiency Breakdown
Estimated Lifetime Carbon Footprint
(Based on 200,000 miles driven)