2016 Chevrolet City Express Cargo Van
Fuel Economy Overview
The 2016 Chevrolet City Express Cargo Van achieves an EPA-estimated 25 MPG in combined city and highway driving, with 24 MPG in the city and 26 MPG on the highway. Powered by a 2L 4-cylinder engine paired with a automatic (variable gear ratios), this special purpose vehicle 2wd features Front-Wheel Drive drive.
In terms of environmental impact, the 2016 City Express Cargo Van produces approximately 353 grams of CO2 per mile. This figure is measured under standardized EPA test conditions and represents tailpipe emissions only. For context, the average new vehicle sold in the United States produces approximately 400 grams of CO2 per mile, meaning this City Express Cargo Van performs better than the national average in this regard.
The estimated annual fuel cost for this vehicle is $2,400, based on 15,000 miles of driving per year and current national average fuel prices. Compared to the average new vehicle, you would save $1,250 over a 5-year period. This calculation accounts for differences in fuel consumption efficiency and provides a practical measure of long-term ownership costs attributable to fuel economy.
Energy DNA
Green Scorecard
Personalized Commute CalculatorEPA defaults to 55% City / 45% Hwy
Adjust the slider to match your daily driving habits. City driving involves stop-and-go traffic under 45mph, while highway driving represents sustained speeds over 55mph.
Aerodynamic Speed Penalty
EPA highway tests average roughly 48 mph. Driving at 75 mph increases aerodynamic drag exponentially. Expect your real-world highway fuel economy to drop by roughly 15-20% at interstate speeds.
5-Year Total Cost of Ownership
Recall Intelligence
Nissan North America, Inc. (Nissan) is recalling certain 2013-2021 NV200 Van, 2014-2017, 2019 NV200 Taxi, and 2015-2018 Chevrolet City Express vehicles. The Fuel Tank Temperature (FTT) sensor harness may have been incorrectly routed, damaging wires and causing a short circuit in the fuel pump fuse.
Consequence & Remedy
Consequence: A blown fuel pump fuse can cause the engine to stall, increasing the risk of a crash.
Remedy: Dealers will inspect and reroute the FTT sensor harness or replace the fuel pump assembly as necessary, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Nissan's customer service at 800-647-7261. Nissan's number for this recall is PMA56. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov October 10, 2025.
General Motors LLC (GM) is recalling certain 2016-2019 Chevrolet Express and GMC Savana vehicles. One or both of the rear-quarter windows may be tempered glass instead of laminated glass. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Consequence & Remedy
Consequence: Tempered glass increases the risk of injury in the event of a side impact or rollover crash.
Remedy: GM will notify owners, and dealers will replace the tempered glass windows with laminated glass windows, as necessary, free of charge. The recall began July 5, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N192218960.
General Motors LLC (GM) is recalling certain 2016-2018 Chevrolet Express and GMC Sierra vehicles equipped with a single, manual, rear climate control module (CCM). If the temperature is set to maximum heat or the mode knob is set to maximum floor vent and an electrical short occurs, components within the CCM may overheat.
Consequence & Remedy
Consequence: If the CCM overheats, there is an increased risk of a fire in the vehicle's headliner.
Remedy: GM will notify owners, and dealers will remove the electrical insulation from a wiring connector within the CCM to remove the fire risk, free of charge. The recall began November 6, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18299.
General Motors LLC (GM) is recalling certain 2014-2017 Chevrolet Express and GMC Savana vehicles equipped with power windows. Liquid may leak into the driver's power window switch and cause corrosion, resulting in high electrical resistance.
Consequence & Remedy
Consequence: High electrical resistance can increase the risk of a fire.
Remedy: GM will notify owners, and dealers will replace the driver side window switch, free of charge. The recall began August 10, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18155.
General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & Remedy
Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.
General Motors LLC (GM) is recalling certain model year 2016-2017 Chevrolet Express manufactured September 25, 2015, to August 22, 2016, and 2016 GMC Savana cargo and cutaway vans manufactured January 28, 2016, to May 18, 2016. The affected vehicles were manufactured without an inside rearview mirror and with a right-hand convex exterior review mirror. These vehicles are required to have either an inside rearview mirror or both left and right-hand flat exterior rearview mirrors. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & Remedy
Consequence: If the driver does not have a clear unobstructed view to the back of the vehicle, it can increase the risk of a crash.
Remedy: GM will notify owners, and dealers will instal a right-hand flat rearview mirror, free of charge. The recall began on November 8, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16036.
Nissan North America, Inc. (Nissan) is recalling certain model year 2016-2017 Nissan Maxima, 2013-2016 Nissan Altima, NV200, LEAF, Sentra, and Pathfinder, 2014-2016 Nissan NV200 Taxi, Infiniti QX60, QX60 Hybrid, and Q50 Hybrid, 2014-2017 Nissan Rogue and Infiniti Q50, 2015-2016 Nissan Murano, Murano Hybrid, and Chevrolet City Express, 2014-2015 Nissan Pathfinder Hybrid, and 2013 Infiniti JX35 vehicles. In these vehicles, the front seat passenger Occupant Classification System (OCS) may incorrectly classify an adult passenger as a child or classify the seat as empty despite it being occupied. As a result, the passenger frontal air bag may be turned off and not deploy in the event of a crash.
Consequence & Remedy
Consequence: If the passenger frontal air bag does not deploy as intended in the event of a crash, the passenger is at an increased risk of injury.
Remedy: Nissan will notify their owners. Chevrolet City Express owners will be notified by General Motors. Dealers will reprogram the Air Bag Control Unit (ACU) and OCS Electronic Control Unit (ECU) in Altima, Maxima, Murano, Rogue, and Sentra vehicles, and replace the OCS ECU in LEAF, NV200, NV200 Taxi, Pathfinder, Infiniti Q50, JX35, and QX60 and Chevrolet City Express vehicles, free of charge. Interim notices were sent to owners on May 31, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Nissan customer service at 1-800-867-7669, Infiniti customer service at 1-888-833-3216 or Chevrolet customer service at 1-800-222-1020.
General Motors LLC (GM) is recalling certain model year 2014-2016 Chevrolet Express and GMC Savana incomplete vehicles equipped with a 159 inch wheel base manufactured August 2, 2013, to January 30, 2016. The affected vehicles were shipped to final stage manufacturers without a tire pressure monitoring system (TPMS). As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
Consequence & Remedy
Consequence: Without a TPMS, the driver would not be alerted if one or more tires became under inflated. Driving with under inflated tires increases the risk of a crash.
Remedy: GM will notify owners, and dealers will install the hardware and software necessary to equip the vehicles with a TPMS, free of charge. The recall began on May 25, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 15819.
Loading live complaint data...
Looking for comprehensive historical data?
NHTSA FARS (Fatal Crash History) and broader generational safety trends are aggregated at the model level rather than by specific engine configurations. View the complete historical data profile for all Chevrolet City Express Cargo Van configurations.
Similar 2016 Special Purpose Vehicle 2WD Alternatives
2016 Ford Transit Connect Van 2WD
1.6L 4-cyl Front-Wheel Drive
2016 Nissan NV200 Cargo Van
2L 4-cyl Front-Wheel Drive
2016 Ford Transit Connect Wagon FWD
1.6L 4-cyl Front-Wheel Drive
2016 Nissan NV200 NYC Taxi
2L 4-cyl Front-Wheel Drive
2016 Ram Promaster City
2.4L 4-cyl Front-Wheel Drive
2016 Ford Transit Connect Van 2WD
2.5L 4-cyl Front-Wheel Drive
Fuel Cost Analysis
Based on 15,000 miles/year and current fuel prices.
Efficiency Breakdown
Estimated Lifetime Carbon Footprint
(Based on 200,000 miles driven)