2018 Chevrolet City Express Cargo Van
Fuel Economy Overview
The 2018 Chevrolet City Express Cargo Van achieves an EPA-estimated 25 MPG in combined city and highway driving, with 24 MPG in the city and 26 MPG on the highway. Powered by a 2L 4-cylinder engine paired with a automatic (variable gear ratios), this special purpose vehicle 2wd features Front-Wheel Drive drive.
In terms of environmental impact, the 2018 City Express Cargo Van produces approximately 356 grams of CO2 per mile. This figure is measured under standardized EPA test conditions and represents tailpipe emissions only. For context, the average new vehicle sold in the United States produces approximately 400 grams of CO2 per mile, meaning this City Express Cargo Van performs better than the national average in this regard.
The estimated annual fuel cost for this vehicle is $2,400, based on 15,000 miles of driving per year and current national average fuel prices. Compared to the average new vehicle, you would save $1,250 over a 5-year period. This calculation accounts for differences in fuel consumption efficiency and provides a practical measure of long-term ownership costs attributable to fuel economy.
Energy DNA
Green Scorecard
Personalized Commute CalculatorEPA defaults to 55% City / 45% Hwy
Adjust the slider to match your daily driving habits. City driving involves stop-and-go traffic under 45mph, while highway driving represents sustained speeds over 55mph.
Aerodynamic Speed Penalty
EPA highway tests average roughly 48 mph. Driving at 75 mph increases aerodynamic drag exponentially. Expect your real-world highway fuel economy to drop by roughly 15-20% at interstate speeds.
5-Year Total Cost of Ownership
Recall Intelligence
Nissan North America, Inc. (Nissan) is recalling certain 2013-2021 NV200 Van, 2014-2017, 2019 NV200 Taxi, and 2015-2018 Chevrolet City Express vehicles. The Fuel Tank Temperature (FTT) sensor harness may have been incorrectly routed, damaging wires and causing a short circuit in the fuel pump fuse.
Consequence & Remedy
Consequence: A blown fuel pump fuse can cause the engine to stall, increasing the risk of a crash.
Remedy: Dealers will inspect and reroute the FTT sensor harness or replace the fuel pump assembly as necessary, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Nissan's customer service at 800-647-7261. Nissan's number for this recall is PMA56. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov October 10, 2025.
General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC Savana, 2019-2020 Chevrolet Blazer, Silverado 1500, GMC Acadia, Sierra 1500, and certain Continental tires sold to the aftermarket for various model year 2018-2021 vehicles. The affected tires were cured for too long during production.
Consequence & Remedy
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will inspect the tires, replacing them as necessary, free of charge. The recall began March 22, 2021. Owners may contact GMC customer service at 1-888-988-7267, Buick customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212329050.
General Motors LLC (GM) is recalling certain 2016-2019 Chevrolet Express and GMC Savana vehicles. One or both of the rear-quarter windows may be tempered glass instead of laminated glass. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Consequence & Remedy
Consequence: Tempered glass increases the risk of injury in the event of a side impact or rollover crash.
Remedy: GM will notify owners, and dealers will replace the tempered glass windows with laminated glass windows, as necessary, free of charge. The recall began July 5, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N192218960.
Unicell Body Company Inc. (Unicell) is recalling certain 2017-2019 Chevrolet Express and GMC Savanna, 2018-2019 Hino 155, Ford Econoline and Transit and Isuzu NPR, and 2018 Ram ProMaster-based vehicles equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The affected monitors may revert back to the factory default settings which may cause the camera image to be reversed.
Consequence & Remedy
Consequence: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.
Remedy: Unicell will work with ASA Electronics to notify owners and offer a remedy, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics customer service 1-800-384-4400 or Unicell at 1-716-853-8628.
General Motors LLC (GM) is recalling certain 2016-2018 Chevrolet Express and GMC Sierra vehicles equipped with a single, manual, rear climate control module (CCM). If the temperature is set to maximum heat or the mode knob is set to maximum floor vent and an electrical short occurs, components within the CCM may overheat.
Consequence & Remedy
Consequence: If the CCM overheats, there is an increased risk of a fire in the vehicle's headliner.
Remedy: GM will notify owners, and dealers will remove the electrical insulation from a wiring connector within the CCM to remove the fire risk, free of charge. The recall began November 6, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18299.
General Motors LLC (GM) is recalling certain 2018 Chevrolet Express and GMC Savana vehicles with certain combinations of front-tire and gross-vehicle-weight option codes. The Tire Pressure Monitoring System (TPMS) may be incorrectly calibrated, causing the TPMS warning lamp to illuminate when tire pressure reaches 37 PSI, not 41 PSI. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
Consequence & Remedy
Consequence: If the low tire pressure telltale is not illuminated at the correct tire pressure, the driver may have less time to react to a low-tire-pressure situation, which could affect the driver's ability to control the vehicle in certain situations and could increase the risk of a crash.
Remedy: GM will notify owners, and dealers will check the PSI information on the remote control door lock receiver (RCDLR) and tire placard match, and if the information is different the RCDLR will be reprogrammed. This repair will be done free of charge. The recall began August 27, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18255.
General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & Remedy
Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.
Loading live complaint data...
Looking for comprehensive historical data?
NHTSA FARS (Fatal Crash History) and broader generational safety trends are aggregated at the model level rather than by specific engine configurations. View the complete historical data profile for all Chevrolet City Express Cargo Van configurations.
Similar 2018 Special Purpose Vehicle 2WD Alternatives
2018 Nissan NV200 Cargo Van
2L 4-cyl Front-Wheel Drive
2018 Nissan NV200 NYC Taxi
2L 4-cyl Front-Wheel Drive
2018 Ram Promaster City
2.4L 4-cyl Front-Wheel Drive
2018 Ford Transit Connect Van 2WD
2.5L 4-cyl Front-Wheel Drive
2018 Ford Transit Connect Van FFV
2.5L 4-cyl Front-Wheel Drive
2018 Ford Transit Connect Wagon FFV
2.5L 4-cyl Front-Wheel Drive
Fuel Cost Analysis
Based on 15,000 miles/year and current fuel prices.
Efficiency Breakdown
Estimated Lifetime Carbon Footprint
(Based on 200,000 miles driven)