Do Not Drive — Critical Safety Warning
The NHTSA has issued a "Park It" advisory for this specific vehicle configuration. There is a catastrophic safety defect that poses an immediate risk of death or severe injury. Scroll down to the Recall Intelligence section for specific remedy instructions.
2020 Ford Expedition 4WD
Fuel Economy Overview
The 2020 Ford Expedition 4WD achieves an EPA-estimated 19 MPG in combined city and highway driving, with 17 MPG in the city and 22 MPG on the highway. Powered by a 3.5L 6-cylinder turbocharged engine paired with a automatic (s10), this standard sport utility vehicle 4wd features Part-time 4-Wheel Drive drive.
In terms of environmental impact, the 2020 Expedition 4WD produces approximately 473 grams of CO2 per mile. This figure is measured under standardized EPA test conditions and represents tailpipe emissions only. For context, the average new vehicle sold in the United States produces approximately 400 grams of CO2 per mile, meaning this Expedition 4WD has higher-than-average emissions in this regard.
The estimated annual fuel cost for this vehicle is $3,150, based on 15,000 miles of driving per year and current national average fuel prices. Compared to the average new vehicle, you would save $5,000 over a 5-year period. This calculation accounts for differences in fuel consumption efficiency and provides a practical measure of long-term ownership costs attributable to fuel economy.
Energy DNA
Green Scorecard
Personalized Commute CalculatorEPA defaults to 55% City / 45% Hwy
Adjust the slider to match your daily driving habits. City driving involves stop-and-go traffic under 45mph, while highway driving represents sustained speeds over 55mph.
The Brick Effect: Highway Speed Penalty
EPA highway tests average roughly 48 mph. Driving at 75 mph increases aerodynamic drag exponentially. Because the Standard Sport Utility Vehicle 4WD has a large frontal area, expect your real-world highway fuel economy to drop by up to 25% at high speeds.
5-Year Total Cost of Ownership
Recall Intelligence
Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.
Consequence & Remedy
Consequence: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy: Dealers will replace the seat belt retractors as necessary, free of charge. Owner notification letters were mailed October 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S31. Some vehicles in this recall that were previously inspected under recall 24V-099 and did not have parts replaced will need to have this new recall remedy completed.
Ford Motor Company (Ford) is recalling certain 2020 Expedition and Lincoln Navigator vehicles. A short circuit within the battery junction box can cause an engine fire while driving or parked.
Consequence & Remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised to park their vehicles outside and away from structures and other vehicles, until the remedy is performed. Dealers will inspect and replace the battery junction box, as necessary, and remove a ground wire. On models equipped with standard-duty radiator fan motors, dealers will also install an auxiliary electrical box with a wire jumper. Repairs will be performed free of charge. Owner notification letters were mailed October 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's numbers for this recall are 22S36 and 22S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 23, 2025.
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & Remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Ford Motor Company (Ford) is recalling certain 2020 Expedition and Navigator vehicles that were repaired incorrectly under recall 20V262. The Pre-Collision Assist features, such as forward collision warning and automatic emergency braking, are not functional due to a software error.
Consequence & Remedy
Consequence: Inoperative pre-collision assist features that fail to perform as expected can increase the risk of a crash or injury.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed June 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S56.
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & Remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently deploy and lock the seat belt, which will not allow the belt to retract or extend.
Consequence & Remedy
Consequence: Seat belts that do not retract or extend may fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy: Dealers will replace the seat belt retractors, as necessary. Additionally, dealers will install an HVAC drain tube elbow if it is missing. Repairs will be performed free of charge. Owner notification letters were mailed on July 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S06.
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & Remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & Remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & Remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Ford Motor Company (Ford) is recalling certain 2020 Expedition vehicles. The seat belt tension sensor may incorrectly classify a child occupant as an adult.
Consequence & Remedy
Consequence: In the event of a crash, the incorrect classification would enable the passenger air bag to deploy instead of disabling it, increasing the risk of injury to the seat occupant.
Remedy: Ford will notify owners, and dealers will replace the seat belt buckle, free of charge. The recall began October 16, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S54.
Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles. The attachment bracket for the driver's side second-row seat headrest may not have been sufficiently welded to the seat frame. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & Remedy
Consequence: An improperly welded headrest bracket may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the seat structure and replace it as needed, free of charge. This recall began July 8, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C12.
Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles equipped with camera-only Pre-Collision Assist feature. Vehicles built with the optional radar-plus-camera Pre-Collision Assist system are not affected. Due to incorrect coding of interfacing modules, the Pre-Collision Assist feature is not enabled, and the driver cannot access the menu functions necessary to enable the Pre-Collision Assist feature.
Consequence & Remedy
Consequence: If the driver is unaware that the Pre-Collision Assist feature is not enabled, they may rely on a system that is not functional, increasing the risk of a crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram software for the Body Control Module, Antilock Braking System, Instrument Panel Cluster and Headlamp Control Modules, and reset the Tire Pressure Monitor System, free of charge. The recall began May 26, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S20.
Ford Motor Company (Ford) is recalling certain 2020 Expedition vehicles. The front passenger seatbelt buckle's Belt Tension Sensor (BTS) may malfunction and may result in the seat occupant being misclassified.
Consequence & Remedy
Consequence: In the event of a crash, the restraint system may not provide the intended level of protection, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will replace the front passenger seatbelt buckle, free of charge. The recall began May 11, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S17.
Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.
Consequence & Remedy
Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & Remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Loading live complaint data...
Looking for comprehensive historical data?
NHTSA FARS (Fatal Crash History) and broader generational safety trends are aggregated at the model level rather than by specific engine configurations. View the complete historical data profile for all Ford Expedition 4WD configurations.
Similar 2020 Standard Sport Utility Vehicle 4WD Alternatives
2020 Bentley Bentayga
3L 6-cyl All-Wheel Drive
2020 Ford Explorer FFV AWD
3.3L 6-cyl Part-time 4-Wheel Drive
2020 Land Rover Defender 110 MHEV
3L 6-cyl 4-Wheel Drive
2020 Land Rover Defender 90
2L 4-cyl 4-Wheel Drive
2020 Land Rover Defender 90 MHEV
3L 6-cyl 4-Wheel Drive
2020 Land Rover Range Rover PHEV
2L 4-cyl 4-Wheel Drive
Fuel Cost Analysis
Based on 15,000 miles/year and current fuel prices.
Efficiency Breakdown
Estimated Lifetime Carbon Footprint
(Based on 200,000 miles driven)